Allegro Microsystems WG Inc.
Update: After January 6, 2017, information about this RCRA Corrective Action site
will be available at:
Corrective Action Sites Around the Nation - Region 3
(Search for the Facility by Name, Location, or EPA ID)
Please be sure to update your bookmarks.
On This Page
EPA Project Manager
Khai M. Dao
Office of Pennsylvania Remediation - 3LC30
U.S. EPA Region III
1650 Arch Street
Philadelphia, PA 19103-2029
From 2003 to 2005 and under the supervision of the Pennsylvania Department of Environmental Protection (PADEP), Allegro completed the investigation and remediation of the property in accordance with the PADEP Land Recycling and Environmental Remediation Standards Act (Act 2). The Pennsylvania Statewide Health Standards (SHS), which are equivalent to the EPA residential standards and deemed protective of public heath, were applied to the investigation and remediation.
The investigation evaluated six areas of concern (AOCs) at the Facility that potentially posed an environmental concern. The six AOCs comprised of four solid waste management units (SWMUs), one aboveground storage tank (AST) and one underground storage tank (UST). PADEP oversaw and certified the closures of the SWMUs, AST and UST in 2003.
In addition to the closure of the aforementioned units, a site characterization was conducted to determine the potential environmental impacts within, or immediately adjacent to the property that may resulted from past operations. The site characterization consisted of a site-wide groundwater monitoring and surface and subsurface soil samples for the constituents of concerns (COCs) that consisted of heavy metals, polycyclic aromatic hydrocarbons (PAHs), and volatile organic compounds (VOCs). The investigation concluded that the soil results for the COCs were below the SHS and do not pose an unacceptable risk to human health. Furthermore and with the exception of the element barium, groundwater results for the COCs were also below the SHS.
Allegro never used barium or its related compounds in any of their industrial processes. However, barium was detected at varies levels throughout the property. Barium exceedances above the SHS of 2000 mg/L were detected in five of the twenty-four monitoring wells and twelve temporary well points. The exceedances range from 2,400 mg/L to 7,000 mg/L. The barium exceedances in groundwater are localized in the shallow aquifer and are confined within a one acre area located in the southeastern quadrant of the Facility. Groundwater flow in this area of the Facility discharges to the unnamed tributary. In utilizing a mass-balance water quality analysis model (PENTOXSD model) to evaluate diffuse groundwater discharge to surface water, PADEP determined that the barium levels in groundwater do not adversely impact the unnamed tributary. The investigation did not identify any potential sources for the barium in groundwater. Therefore, PADEP concluded that the barium detections in groundwater are naturally occurring in nature.
The former Facility has since been redeveloped into a shopping center that includes a Walmart Supercenter and several big box retailers. The property is zoned for non-residential use and will remain non-residential for the foreseeable future. A deed restriction on the property prohibits the use of onsite groundwater for any purposes and therefore, prevents direct human exposures to barium. Historic groundwater results confirm that the elevated barium levels in groundwater are stabilized within the one acre area. The barium levels in groundwater do not adversely impact the surrounding environment.
Based the above assessment, EPA has proposed no further corrective action or land use controls are necessary at this time at the Facility. EPA has determined that its proposed decision is protective of human health and the environment.
The former Allegro facility occupied approximately 30 acres located in Willow Grove, PA. Much of the former property (approximately 60%) was open landscape and asphalt-paved areas that included parking lots and access roadways. Approximately 40% of the former property was used for manufacturing and product distribution. The operations structures consisted of a large single-story building, a pump house, the wastewater treatment plant (WWTP) and a small stone shed. A detailed layout of the former Allegro facility is presented in Figure 1.
From 1990-2001, Allegro manufactured large-scale integrated circuits used in various applications such as automobile ABS systems, smoke detectors, computer memories, space and telecommunications hardware, oil exploration, and battery operated devices. The circuits were processed on the surfaces of polished silicon wafers. The wafers were mass-produced using photolithography techniques, high temperature heat treatments, and chemical etching.
In October 2001, Allegro discontinued operations and commenced decommissioning of the facility. In September 2002, Allegro sold the property to a commercial developer who redeveloped the former facility into its current usage as a shopping center that includes a Walmart Supercenter and several big box retailers.
- Some of the site’s key documents of interest are accessible below:
- Corrective Action Statement of Basis [PDF, 8 pages, 652 KB, About ]
- Environmental Indicator Determination - Human Exposures [PDF, 7 pages, 158 KB, About ]
- Environmental Indicator Determination - Groundwater [PDF, 8 pages,512 KB, About ]
- Documents and reports regarding this facility also can be reviewed in person at these locations:
U.S. EPA Region III
Land & Chemicals Division
1650 Arch Street-11th Floor
Philadelphia, PA 19103
Call for an appointment.
- Submit a FOIA Request
Get instructions on how to submit a FOIA request. Additional fee for requests over 100 pages.
|Allegro Microsystems WG Inc.|
Click on a thumbnail to enlarge the photo)
The site is being reused.
The EPA is dedicated to providing you with timely and accurate information about our work at this site. If you have any questions or concerns, please contact EPA Project Manager: Mr. Khai M. Dao